IF YOU FEEL ANY OF THESE SYMPTOMS, MOVE INTO FRESH AIR IMMEDIATELY. IF SYMPTOMS PERSIST, GET MEDICAL HELP. Do not operate the generator until its exhaust system has been inspected and properly repaired. -A CAUTION A- A Never tee the generator engine exhaust pipe into the vehicle engine exhaust piping. This causes excessive back pressure on the generator engine. Also, water from one engine can damage the other engine. ♦ 6.6.1 MUFFLERS AND SPARK ARRESTORS This muffler meets code and standard r

(1) Designed, built and equipped so as to conform with all applicable regulations adopted by the CARB pursuant to its authority, and (2) Free from defects in materials and workmanship which, at any time during the ECS Warranty Period, may cause a warranted emissions-related part to fail to be identical in all material respects to the part as described in the engine manufacturer’s application for certification. (c) The ECS Warranty only pertains to emissions-related parts on your engine, as follo

17 042558 1 KEY SQ 3/8 X 1 STEEL 18 0A5061 1 SPACER-FLEX PLATE 19 0A4989 1 PLATE, FLEX 20 053557 1 SCREW HHC M12-1.75 X 40 G8.8 21 051769 6 WASHER LOCK M12 22 049541 4 SCREW HHC M10-1.5 X 35 G8.8 23 046526 4 WASHER LOCK M10 24 045772 4 NUT HEX M10-1.5 G8 YEL CHR 26 * 087599 1 PLUG PLASTIC 3/8 NPT 27 077043E 1 FLEX CONDUIT 1" BLACK (NOT SHOWN) 28 022131 4 WASHER FLAT 3/8-M10 ZINC 29 072578 1 SPACER ROTOR SHAFT 30 0A7043 5 SCREW HHC M12-1.25 X 25 G8.8 31 049808 5 WASHER FLAT M12 32 058589 1 DECAL

71 049226 2 WASHER, LOCK M5 054450 1 CIRCUIT BREAKER 5.5A. 72*** 0D5324 1 FUSE & HOLDER LITTLE 7.5A 30 022241 1 HEX NUT 3/8"-16 73*** 0A9611 REF FUSE 7.5AXBK/AGC7.5NX 31 022097 8 WASHER, LOCK 1/4-M6 32 022473 8 WASHER, FLAT 1/4-M6 *NOT SHOWN ON THIS ASSEMBLY 33 0A1354A 1 REGULATOR-DC ALT. **SEE CHART 34 043116 4 HHCS, M6-1.0 x 12MM ***PART OF CONTROL PANEL WIRE HARNESS 35 056739 1 SOLENOID RELAY 12VDC Generac® Power Systems, Inc. 31 32 Generac® Power Systems, Inc. 33 12 68 69 41 VIEW ON "B" 1 20

3 GENERAL INFORMATION Section 1 - General Information QUIETPACT™ 75D Recreational Vehicle Generator 1.1 GENERATOR IDENTIFICATION Please record the following information from the generator DATA DECAL or information decal, located below the user control panel. 1. Model Number ___2. Serial Number __ 3. kW Rating. Rated Voltage 15 12 3 22 FRONT VIEW 21 ,16 Model: 04270-0 QUIETPACT™ 75D 1. 2-Pole, 35-amp Circuit Breaker 2. Hourmeter 3. Oil Fill Opening and Plug 4. Oil Dipstick 5.

! Gaseous fuels such as natural and LP (propane) gas are highly explosive. Even the slightest spark can ignite such fuels and cause an explosion. No leakage of fuel is permitted. Natural gas, which is lighter than air, tends to collect in high areas. LP gas is heavier than air and tends to settle in low areas. ENGINE PROTECTIVE DEVICES The engine has several safety switches which cause the engine to automatically shut down under the following conditions: low oil pressure, high coolant temperatur

of Teeth on Flywheel ..............................................................104 Ignition Timing at 1800 rpm ........................................................35 degrees BTDC at 3600 rpm ........................................................43 degrees BTDC Spark Plug Gap ......................................................0.020-0.025 inch Recommended Spark Plugs Champion ........................................................................RN11YC4 Oil Pressure .................

Battery voltage is delivered to that circuit board via a 15-amp fuse. These overcurrent protection devices will open if the circuit is overloaded. If a circuit breaker opens or a fuse element melts, find the cause of the overload before resetting the circuit breaker or replacing the fuse. 4.8 DC FUSE The generator panel’s 15-amp AGC fuse (Figure 4.4) protects the DC control circuit against overload. The fuse is wired in series with the battery output lead to the panel. If the fuse element has me

Each single winding can supply a 120-volt, 60-Hertz AC output. 4 Generac® Power Systems, Inc. When the two windings are connected in series, a 240volt, 60-Hertz AC output results. Typically, the two “hot” leads in the circuit are Wires 11 and 44. The neutral leads are the junction of Wires 22 and 33. Figure 1.1 – Single-phase Generator AC Connection System Neutral Block 1.4 PREPACKAGED TRANSFER SWITCH The transfer switch shipped with this generator is rated 200 amps maximum at 120/240 volts AC s

45 17 KIT PART NO. 0D7947 20 18 19 KIT PART NO. 0D7948 30 31 33 35 34 32 37 9 10 11 14 16 38 39 36 27 40 29 1 10 16 27 "A" 22 15 3 7 24 22 23 TO "A" KIT PART NO. 0D8121 10 21 17 46 Generac® Power Systems, Inc. Section 7 — Exploded Views and Parts Lists Guardian Liquid-cooled 40 kW Generators 4.3L Radiator – Drawing No. 0D7992-D Section 7 — Exploded Views and Parts Lists Guardian Liquid-cooled 40 kW Generators 4.3L Radiator – Drawing No. 0D7992-D ITEM PART NO. QTY. DESCRIPTION 1 0D7825 1 RADIATOR